Acquire images in LabView from DirectShow Interface

Image acquisition in LabView

Run the downloaded .exe-file as shown in Figure 1.

The uEye Setup will be started.

Follow the steps; you are guided through to install the uEye DirectShow Interface (see Figure 4).

If necessary select “Register cameras on connect” or “Use camera names” (Figure 5) in this step. These settings can also be changed afterwards.

Wait until the installation is completely done. Click “Finish” to complete the installation and exit the wizard (Figure 7).

The correct installation of the uEye DirectShow Interface can be rechecked in the IDS Camera Manager → Additional Information.

This link will lead to the download area of the NI Vision Acquisition Software 2016.08.
Click on the VAS_2016_08_downloader.exe.
The VAS_2016_08.zip file will be downloaded.
Open the zipped folder that is called “VAS_2016_08” and double-click the setup.exe (see Figure 8).

The NI Vision Acquisition Software Setup will guide you through the installation (see Figure 9). Follow the steps to install the NI Vision Acquisition Software.

Select the required features to install (Figure 11). If clicking the button “Restore Features Defaults” some default features will be chosen. These features will be required to acquire images from the DS interface. No changes have to be made here.

Click “Next” to go ahead.

Read the Product Notifications and click “Next”. There might be no notifications for this product. Read the License Agreement and accept them (see Figure 13).

Click “Next” to continue. Recheck the installation components (see Figure 14).

Click “Next” to go ahead. The installation process will be started automatically.

If not already done, activate the LabView license with the “NI License Manager” (see Figure 16). After the installation has been completed, finish the installation setup by clicking “Next” and “Finish”.

 

3) How to access a uEye camera in LabView via the DS interface

Make sure that all connected cameras are registered in the uEye DS interface. This can be done with the uEye DS Device Manager (Start → Programs → IDS → uEye → uEye DS Device Manager (run as admin)).

To acquire images from a uEye camera in LabView over the DS interface, the easiest way is to use the “Measurement and Automation Explorer” (NI MAX). This piece of software can be opened with an icon on your desktop (Figure 17), or Start → Programs → National Instruments → Measurement & Automation.

Once the NI MAX has been opened, select the configuration window to find a uEye camera. Open the path “My System” → “Devices and Interfaces” → “NI-DAQmx Devices” and select one of the uEye cameras. Click the button “Grab” to get a live video (see Figure 18).